International Journal of Science and Research (IJSR)

International Journal of Science and Research (IJSR)
Open Access | Fully Refereed | Peer Reviewed

ISSN: 2319-7064


Downloads: 119

Research Paper | Civil Engineering | India | Volume 3 Issue 9, September 2014


An Experimental Study on Economic Feasibility and Strength of Concrete by Partial Replacement of Cement with Hypo Sludge

Mahesh Shirur, Yashwanth M. K


Abstract: To produce low cost concrete by blending various ratios of cement with hypo sludge and to reduce disposal and pollution problems due to hypo sludge it is most essential to develop profitable building materials from hypo sludge. The innovative use of hypo sludge in concrete formulations as a supplementary cementitious material was tested as an alternative to normal concrete. In this study, hypo sludge is physically and chemically characterized and partially replaced in the ratio of 0 %, 10 %, 20 %, 30 %, 40 %, 50 %, 60 % and 70 % by weight of cement, natural River sand as fine aggregate and normal coarse aggregate were used to produce concrete. Mix design of concrete is done as per bureau of Indian standards; the fresh properties of concrete like slump test and compaction factor test and hardened properties like compressive strength and split tensile strength were carried out. The test results indicated that fresh and hardened properties of the concrete increases as the percentage of replacement of hypo sludge increases up to 30 % and economic feasibility of hypo sludge based concrete is less compared to conventional concrete.


Keywords: Hypo sludge, Fresh properties, compressive Strength, split tensile strength, economic feasibility


Edition: Volume 3 Issue 9, September 2014,


Pages: 1289 - 1291


How to Cite this Article?

Mahesh Shirur, Yashwanth M. K, "An Experimental Study on Economic Feasibility and Strength of Concrete by Partial Replacement of Cement with Hypo Sludge", International Journal of Science and Research (IJSR), https://www.ijsr.net/get_abstract.php?paper_id=8091401, Volume 3 Issue 9, September 2014, 1289 - 1291

How to Share this Article?

Enter Your Email Address


Similar Articles with Keyword 'Fresh properties'

Downloads: 119

M.Tech / M.E / PhD Thesis, Civil Engineering, India, Volume 5 Issue 8, August 2016

Pages: 954 - 959

Behaviour of Self-Compacting Concrete at Various Levels of Replacement to Fine Aggregate by Pond Ash and Quarry Dust

Vivekanandareddi Patil, Rohan S Gurav

Share this Article

Downloads: 121

M.Tech / M.E / PhD Thesis, Civil Engineering, India, Volume 5 Issue 7, July 2016

Pages: 1870 - 1875

Assessment of Fresh Properties of Pond Ash SCC

Jai Prakash Reddy, Maneeth P D

Share this Article

Similar Articles with Keyword 'compressive Strength'

Downloads: 1 | Monthly Hits: ⮙1

Masters Thesis, Civil Engineering, India, Volume 10 Issue 9, September 2021

Pages: 946 - 950

An Experimental Study on High Early Strength of Concreta

Sathyanarayan K. R., B. V. Pramod

Share this Article

Downloads: 2

Research Paper, Civil Engineering, India, Volume 10 Issue 5, May 2021

Pages: 877 - 879

Experimental Investigation on Partial Replacement of Cement by Prosopis Juliflora in Self Compacting Concrete

Dharaneswari .V .K, Sharmila Devi .K

Share this Article

Similar Articles with Keyword 'split tensile strength'

Downloads: 89

Research Paper, Civil Engineering, India, Volume 9 Issue 11, November 2020

Pages: 657 - 663

Experimental Investigation on Mechanical Properties of Hybrid Fibre Reinforced Concrete Due to the Influence of High Volume Fly Ash

D Nissi, K Venkatesh

Share this Article

Downloads: 113

M.Tech / M.E / PhD Thesis, Civil Engineering, India, Volume 5 Issue 4, April 2016

Pages: 955 - 959

Impact of Clay Particles in Concrete

S. Selvamamundi, Dr. N. Mahendran, Dr. S. Anuradha

Share this Article

Similar Articles with Keyword 'Hypo'

Downloads: 60

Research Paper, Civil Engineering, Cameroon, Volume 7 Issue 2, February 2018

Pages: 595 - 602

Numerical Simulation of a Building Collapse on Sandy Clay of Douala City in Cameroon

A. Abanda; Dr. D. Fokwa; P. Eba'a

Share this Article

Downloads: 128

Dissertation Chapters, Civil Engineering, Tanzania, Volume 7 Issue 9, September 2018

Pages: 1555 - 1559

Influence of Earned Value Management on the Performance of Construction Projects in Tanzania; Case of Construction Projects in Arusha City

David Saiguran Lemilia, Dr. Samuel Obino Mokaya

Share this Article

Similar Articles with Keyword 'sludge'

Downloads: 3 | Monthly Hits: ⮙2

Research Paper, Civil Engineering, India, Volume 10 Issue 5, May 2021

Pages: 290 - 293

Study and Design of Destroy and Treatment Bio and Chemical Waste Plant in Hospitals

Ihab Ali Hasan

Share this Article

Downloads: 4

Research Paper, Civil Engineering, India, Volume 10 Issue 7, July 2021

Pages: 318 - 323

Estimation of Biomass Composition and Biological Sludge Production in SBR Plants of India

Ghazal Srivastava, Absar Ahmad Kazmi

Share this Article

Similar Articles with Keyword 'Fresh'

Downloads: 4

Masters Thesis, Civil Engineering, India, Volume 10 Issue 7, July 2021

Pages: 260 - 265

Utlization of Sugarcane Bagasse Ash in Concrete as Partial Replacement in Cement

Bazil Javaid Wani

Share this Article

Downloads: 108

Research Paper, Civil Engineering, India, Volume 4 Issue 6, June 2015

Pages: 2354 - 2359

The Water Quality Loss Due to Dust Pollution in South Katraj Region

G. N. Supe, Prof. S. M. Gawande

Share this Article

Similar Articles with Keyword 'properties'

Downloads: 242 | Weekly Hits: ⮙2 | Monthly Hits: ⮙3

Research Paper, Civil Engineering, India, Volume 9 Issue 6, June 2020

Pages: 954 - 955

Bamboo as a Building Material in North East of India

Nafisa Nazneen Choudhury

Share this Article

Downloads: 187

Case Studies, Civil Engineering, India, Volume 8 Issue 4, April 2019

Pages: 141 - 154

Case Study Papers on Practical Guidelines for the Inspection and Repair of Hot Dip Galvanized Coatings

Harshal S Khode

Share this Article

Similar Articles with Keyword 'compressive'

Downloads: 1 | Monthly Hits: ⮙1

Masters Thesis, Civil Engineering, India, Volume 10 Issue 9, September 2021

Pages: 946 - 950

An Experimental Study on High Early Strength of Concreta

Sathyanarayan K. R., B. V. Pramod

Share this Article

Downloads: 2

Research Paper, Civil Engineering, India, Volume 10 Issue 5, May 2021

Pages: 877 - 879

Experimental Investigation on Partial Replacement of Cement by Prosopis Juliflora in Self Compacting Concrete

Dharaneswari .V .K, Sharmila Devi .K

Share this Article

Similar Articles with Keyword 'Strength'

Downloads: 242 | Weekly Hits: ⮙2 | Monthly Hits: ⮙3

Research Paper, Civil Engineering, India, Volume 9 Issue 6, June 2020

Pages: 954 - 955

Bamboo as a Building Material in North East of India

Nafisa Nazneen Choudhury

Share this Article

Downloads: 145

Research Paper, Civil Engineering, Sudan, Volume 8 Issue 10, October 2019

Pages: 1006 - 1012

Predicting the Strength Properties of Swelling Clay

Omer S. M. Hamza, Magdi M. E. Zumrawi, Awad E. M. Mohamed

Share this Article

Similar Articles with Keyword 'split'

Downloads: 89

Research Paper, Civil Engineering, India, Volume 9 Issue 11, November 2020

Pages: 657 - 663

Experimental Investigation on Mechanical Properties of Hybrid Fibre Reinforced Concrete Due to the Influence of High Volume Fly Ash

D Nissi, K Venkatesh

Share this Article

Downloads: 101

Research Paper, Civil Engineering, India, Volume 4 Issue 9, September 2015

Pages: 1548 - 1551

Local Scour and its Reduction by using Splitter Plate

Priyanka R. Muke, Tushar D. Bhosale

Share this Article

Similar Articles with Keyword 'tensile'

Downloads: 2

Research Paper, Civil Engineering, India, Volume 10 Issue 7, July 2021

Pages: 859 - 860

Role of Retrofitting of Non-Engineered Construction for Improving Seismic Performance in Developing Countries

Asrar Ul Haq

Share this Article

Downloads: 89

Research Paper, Civil Engineering, India, Volume 9 Issue 11, November 2020

Pages: 657 - 663

Experimental Investigation on Mechanical Properties of Hybrid Fibre Reinforced Concrete Due to the Influence of High Volume Fly Ash

D Nissi, K Venkatesh

Share this Article

Similar Articles with Keyword 'strength'

Downloads: 242 | Weekly Hits: ⮙2 | Monthly Hits: ⮙3

Research Paper, Civil Engineering, India, Volume 9 Issue 6, June 2020

Pages: 954 - 955

Bamboo as a Building Material in North East of India

Nafisa Nazneen Choudhury

Share this Article

Downloads: 145

Research Paper, Civil Engineering, Sudan, Volume 8 Issue 10, October 2019

Pages: 1006 - 1012

Predicting the Strength Properties of Swelling Clay

Omer S. M. Hamza, Magdi M. E. Zumrawi, Awad E. M. Mohamed

Share this Article

Similar Articles with Keyword 'economic'

Downloads: 1

Research Paper, Civil Engineering, India, Volume 3 Issue 9, September 2014

Pages: 2067 - 2069

Adsorption of Fluoride from Aqueous Phase by Agro Based Adsorbent

G. Anusha, J. Raja Murugadoss

Share this Article

Downloads: 1 | Weekly Hits: ⮙1 | Monthly Hits: ⮙1

Research Paper, Civil Engineering, Libya, Volume 10 Issue 10, October 2021

Pages: 350 - 355

Deterrent to Pedestrian Used More Extensively as Travel Mode in Misurata

Abdallah. N. Kamba

Share this Article

Similar Articles with Keyword 'feasibility'

Downloads: 98 | Weekly Hits: ⮙1 | Monthly Hits: ⮙1

M.Tech / M.E / PhD Thesis, Civil Engineering, Indonesia, Volume 9 Issue 7, July 2020

Pages: 476 - 481

Financing Projects of Road Improvement Special Economic Areas Tanjung Lesung Banten with the SBSN Scheme (Surat Berharga Syariah Negara). Case Study: Preservation and Widening of the Road to Pasauran Section - Sp Labuhan - Cibaliung and Citeureup - Tanjung Lesung

Heriyanto, Dr. Ir. Hari Nugraha Nurjaman MT, Dr. Ir. Fitri Suryani MT

Share this Article

Downloads: 109

Research Paper, Civil Engineering, India, Volume 4 Issue 11, November 2015

Pages: 2461 - 2468

Feasibility Study on Provision of Park and Ride Facility at Hebbal Intersection ? Bengaluru

Manjunath S Sharanappanavar

Share this Article
Top