Abstract: To Study High Temperature Erosion-Corrosion of Detonation Gun Sprayed Al2O3 Coated and Uncoated T-91 Boiler steel in Actual Environment of Boiler
International Journal of Science and Research (IJSR)

International Journal of Science and Research (IJSR)
Open Access | Fully Refereed | Peer Reviewed

ISSN: 2319-7064

Downloads: 96

Research Paper | Materials Engineering | India | Volume 3 Issue 3, March 2014

To Study High Temperature Erosion-Corrosion of Detonation Gun Sprayed Al2O3 Coated and Uncoated T-91 Boiler steel in Actual Environment of Boiler

Gurkamal Nain Singh, Tarlochan Singh

Erosion and corrosion is the commonly experienced causes of failure at a premature stage of component life, when component subjected under high temperature environment. To achieve higher performance and efficiency of components raise the demand of protective surfaces (coatings). In the present work, a boiler steel T-91 was been taken as a sample material for its erosion-corrosion study in actual environment. Detonation gun thermal spraying process was used for coating of Al2 O3 powder on T-91 boiler steel. The coated and uncoated samples were subjected to cyclic erosion-corrosion in actual environment i. e. in boiler for 10 cycles. The SEM/EDAX and thermo gravimetric techniques were used to analyse the corrosion -erosion products. After the analysis, it was found that Al2 O3 coating was less effective than the uncoated samples of T-91 steel for providing the protection against erosion-corrosion in actual environment of boiler.

Keywords: Erosion corrosion, Detonation-gun, Al2 O3 coating, T-91 Steel

Edition: Volume 3 Issue 3, March 2014

Pages: 260 - 264

Share this Article

How to Cite this Article?

Gurkamal Nain Singh, Tarlochan Singh, "To Study High Temperature Erosion-Corrosion of Detonation Gun Sprayed Al2O3 Coated and Uncoated T-91 Boiler steel in Actual Environment of Boiler", International Journal of Science and Research (IJSR), https://www.ijsr.net/search_index_results_paperid.php?id=20131109, Volume 3 Issue 3, March 2014, 260 - 264

Enter Your Email Address


Similar Articles with Keyword 'corrosion'

Downloads: 90

Research Paper, Materials Engineering, Egypt, Volume 3 Issue 5, May 2014

Pages: 1087 - 1091

Influence of Nonionic Surfactant on the Carbon Steel Corrosion in Hydrochloric Acid Solution

Ahmed A. Farag, I. M. Ibrahim

Share this Article

Downloads: 98

Research Paper, Materials Engineering, Malaysia, Volume 3 Issue 12, December 2014

Pages: 1800 - 1804

Effect of Nickel on Corrosion Resistance of Al-Zn-Mg-Cu PM Alloy Produced by Mechanical Alloying

Kahtan S. Mohammed, Haider T. Naeem, Raid T. Hadi

Share this Article
Top